|
Jaguar XJ6
XJ12
Technical Service Bulletin (TSB) |
|
1-224NAS |
Mandatory Tool - Midtronics PSC-550 Vehicle
Power Supply |
|
3-120 |
Motorized Automatic Diagonal Seat Belts -
Limited Lifetime Warranty |
|
3-158 |
Wood Veneer Repair
Program |
|
04-15 |
Tires and Wheels Flat Spotting |
|
04-17 |
Transit Spark Plugs - No Longer Fitted to AJS
V12 |
|
04-20 |
Clutch Hydraulic Hose Install Protective
Sleeve - Service Action S452 |
|
04-21 |
Pirelli P5 Discontinued - Replace with P4000
Super Touring |
|
12-47a |
Rough Idle - Install Softer Front Engine
Mounts |
|
12-50 |
Oil Leak - Generator Bracket Bolts - Seal
With Loctite 545 |
|
12-51 |
Tappet Block to Cylinder Head Joint - Use
Loctite 518 Master Gasket |
|
12-52 |
Engine Sump Drain Plug - All AJ6 Engines -
Revised Torque Specifications |
|
12-53 |
Engine Crankcase - Oil Leaks - Sealing
Procedure |
|
12-54 |
Spark Plug - AJ16 Engine - Change in
Specification |
|
12-55 |
Spark Plugs - Revised Specification |
|
12-56 |
Camshaft and Valve Clearance - Revisions |
|
12-57 |
Poor Idle Quality - Normally Aspirated AJ16
Engine - Valve Timing Modification |
|
12-58 |
Engine Oil - viscosity/Temperature Ranges -
Revisions |
|
12-60 |
Camshaft Cover Oil Leaks - AJ16 Engine -
Revised Bolt Torque Specification |
|
12-61 |
Rattle After Start - Upper Timing Chain -
Install Revised Tensioner |
|
12-62 |
Cylinder Head Bolts - Reuse Twice -
Conditions |
|
12-63 |
Main Bearing Cap Bolts - Reuse Twice -
Conditions |
|
12-64 |
Upper Chain Guide Bolts - Apply Locking
Compound |
|
17-8 Amended |
Poor Hot Start - Tank Pressure Control Valve
- Check Operation |
|
17-9 |
Air Pump Clutch - Intermittent Operation -
Service Action S458 |
|
17-10 |
Insufficient Air Flow - AIR Pump (AIRP) -
Diagnosis |
|
17-11 |
Throttle difficult to Open on Cold Engine -
Normally Aspirated Engines - Modify Crankcase Breather System |
|
17-12 |
Recall T493 - 1995 MY/Recall R493 - 1996 MY -
AJ16 EGR System - Replace PROMs and EGR Valve |
|
18-04 |
Security System - Rear Door False Alarm -
Repair Information |
|
18-05 |
Security System - Panic Alarm - Diagnostic
Procedure - Service Action S635 |
|
18-06 |
Security - Handset Transmitter - Manual
Programming |
|
18-09 |
Security Transmitter - Battery Replacement |
|
18-10 |
Security System - Fault Diagnosis Guide |
|
18-12 |
Security System - Frequency Change - Rear
Glass Antenna |
|
18-36a |
Check Engine Light On - DTC 12 Flagged -
Install Changeover Relay and Link Lead |
|
18-38 |
Momentary Engine Power Loss or Stalling
Diagnosis and Repair |
|
18-39 |
Engine Management DTC 69 - Low Battery
Voltage |
|
18-40 |
Engine Management DTC 13 - Manifold Vacuum
Sensing Hose Crimped - Check Vacuum Hose Routing |
|
18-41 |
Intermittent Power Loss - Tach Drops to Zero
- Reposition Ignition Amplifier - Service Action S 439 |
|
18-42 |
PDU 1001 Software - Error - Does Not
Recognize V12 6.0L DTC 67 |
|
18-43 |
Rough Idle/Engine Misfire - New Spark Plug
Wires and Routing |
|
18-45a |
Heated Oxygen Sensor (H02S) - Torque
Specification |
|
18-46 |
Fuel Injectors - Identification |
|
18-47 |
Secondary Air Injection (Air) - DTC P0411 -
Repair Procedure |
|
18-48am |
Uneven Cold Idle - Drivability Enhancements -
ECM Upgrade |
|
18-49a |
MIL Illumination - DTC P0300 Service Action
S659 |
|
18-51a |
MIL Illumination - DTC P0441 - Service Action
S672 |
|
18-52am |
Momentary Engine Hesitation/Instability -
Service Action S676 |
|
18-53 |
DTC's P1176, P1177, P1178, P1179 - Adaptive
Fuelling System - Diagnostic Procedure |
|
18-54 |
Poor Starting and Running - XJR-S - Twin Coil
Modification |
|
18-55 |
Spark Plug "Blow-By Stain"/Corona Stain -
Spark Plug Function Not Affected - Replacement Unnecessary |
|
18-56 |
Rough Idle/Drivability - Diagnosis MAF |
|
18-57 |
MIL Illuminated - H02S - DTC 44 and / or 45 -
Add Ground Straps - Service Action S494 |
|
19-27 |
Fuel Pump Modules - XJR-S - Install
Modification Kit - Service Action S385 |
|
19-28a |
Fuel Pressure Regulator - Hard Starting /
Long Cranking Time, Hot/Warm Engine - Repair Procedure |
|
19-29 |
Fuel Tank - Replacement Procedure |
|
19-31 |
Poor Running in Wet Hot Weather Conditions -
Replace Air Cleaner Housing |
|
19-33 |
Intermittent High Idle - Replace Throttle
Return Springs |
|
19-34 |
Fuel Tank pipe Seals - Replacement Procedure |
|
19-36 |
Poor Drivability - Check Throttle
Synchronization |
|
19-38 |
Intermittent High Idle - Replace Throttle
Return Spring |
|
19-39 |
Special Tool JD 208 - Fuel Pressure Testing -
Method of Use |
|
19-40am2 |
Throttle Deposits/Stuck Closed AJ16 Engines -
Revised Idle Speed Adjustment Procedure |
|
04.1-01 |
Radiator Drain Plug - Specification Change -
Replace - Service Action S652 |
|
26-14 |
Cooling System - "Bow spring" Hose Clamps
Introduced |
|
26-15 |
coolant Expansion Tank - Seam Weld Leaks
Service Action S451 |
|
26-17 |
Coolant Specification Change - Coolant D542
(Yellow) |
|
44-21 |
Automatic Transmission - Shift Quality -
Install Modified TCM |
|
44-22 |
Automatic Transmission Oil Cooler - Internal
Leaks - Remove Tie Strap |
|
44-23 |
Automatic Transmission - engine Stalls When
Engaging "R" or "D" - Repair Procedure |
|
44-24 |
Automatic Transmission - Defaults to "Limp
Home" in Wet Weather - Repair Procedure |
|
44-25 |
ZF Automatic Transmission - Noise in Reverse
After Cold Start in Cold Weather - Repair Procedure |
|
44-26 |
ZF Automatic Transmission - Internal Damage
Due to High engine Speed in Park or Neutral |
|
44-27 |
ZF 4HP 24 E9 Automatic Transmission - Poor
Shift Quality in R, 3 - 4 |
|
44-29 |
Transmission control Module - DTC P1777 -
Update Module |
|
57-18 |
Steering - Lower Column - Excessive
Play/Knocking - Repair Procedure - Service Action S398 |
|
57-20a |
Steering Rack - Surface Cracks - Service
Action S450 |
|
57-22 |
power Assisted Steering - Diagnosis |
|
60-5a |
Suspension - Alignment specifications |
|
60-6am |
Front suspension - Vehicle Pulls to One Side
- Check Pull Index |
|
60-7 |
Steering Pull - correction Procedure |
|
64-14 |
Rear Struts - Installing Non-Leveling Dampers
- Repair Procedure |
|
64-15 |
Rear suspension - Special tools JD199 &
JD199-1 - Repair Procedure |
|
64-16 |
Rear axle Shaft vibration - Fully Laden
Vehicle - Install Longer Rear Springs |
|
64-17 |
Knocking noise - Rear Subframe Bushing -
Modification Procedure |
|
66-22 |
Ride Leveling Struts Stay at Maximum Height
and/or Pressure Relief Valve Cycles - Charge Valve Blocked -
Clean Hydraulic System / Install Filters |
|
70-24 |
New Brake fluid specification - Super DOT 4 |
|
70-25 |
Front Brake Rattle - Disc Shield - Install
new Retaining Screws |
|
70-27 |
A.B.S. Valve Block assembly - Replace
Separately |
|
70-28a |
Brake Pedal Switch Parts Inventory Simplified |
|
3-120 |
Motorized Automatic Diagonal Seat Belts -
Limited Lifetime Warranty |
|
76-105 |
Hood Liner - Modification - Service Action
S437 |
|
76-108 |
Revised Underscuttle - Revised Mounting
Method - Installation Instructions |
|
76-109 |
Hood Panel - difficult to Latch / Contacts
Plenum Grill - Re-profile Hood |
|
76-110 |
Front Seat Belt - Too Short and / or Twisted
- Repair Procedure |
|
76-112 |
Paint Colors - Codes - Du Pont Stock Numbers |
|
76-115 |
Front Seat Belt Twisting –Install Seat Belt
Guides |
|
76-121 |
Interior Trim/Convertible Top Cleaning
–Recommended Products & Procedures |
|
76-122 |
Broken Door Flap Handle –Replace Handle Only |
|
76-123 |
Damaged Cup holder .Replace Mechanism Only
.Repair Procedure |
|
76-124 |
Convertible Soft Top .Replacing Outer Cover
. Guidelines |
|
76-125 |
Windshield VIN Plate .Use Caution
When Replacing Windshield |
|
76-126 |
Glass Bonding .Procedures & Materials |
|
76-127 |
Squeaking Interior Trim .KRYTOX®
Fluid For Trim Refinement Applications |
|
76-128a |
RECALL R469 . Hood Liner .Change of
Specification . Replace |
|
76-129 |
Seat Track Assembly –Repair/Replace
Guidelines |
|
76-64 |
Tibbe Door Locks |
|
76-91 |
Motorized Automatic Diagonal Seat Belts |
|
76-92 |
Front Seat Belt Height Adjuster – Rattles
–Repair Procedure |
|
76-93 |
Convertible Top – Outer Cloth Cover/Interior
Headliner – Replacement |
|
76-94 |
Wind Noise Around Windshield –Repair
Procedure |
|
76-96 |
Hood Panel – Difficult To Latch – Revised
Latch and Hood Release Lever Guard Introduced –Service Action
S448 |
|
82-38 |
Climate Control – Panel Assembly Vibration /
Intermittent Operation –Repair Procedure |
|
82-39am |
R-134a Retrofits Kits |
|
82-43 |
PAG Oil for R134a Systems |
|
82-45 |
Climate Control System – Revised Pipe and
Pressure Switch Location |
|
82-50R |
Receiver/Drier . A/C System Servicing.
Preventing Entry of Moisture |
|
82-51 |
Compressor Refrigerant Leaks .Sanden 709 R12
Compressors .Seal & Gasket Kits Available |
|
82-52 |
Leak Detection System .Ultraviolet Dye |
|
84-12a |
Heated Windshield Washer (Screen wash) Jets –
Ambient Temperature Sensor Added –Service Action S447 |
|
86-130 |
Security Control Module –Repair Procedure |
|
86-133 |
Security System – Transmitter – Diagnostic
Procedure |
|
86-140 |
Cooling Fans –
Inoperative or Operate With Ignition Off – Reseal Ground Wires |
|
86-144a |
CELLULAR TELEPHONE –TRANSCEIVER MULTIPLUG –
RELOCATED |
|
86-146 |
Automatic Transmission Gearshift Interlock–
Gear Selector Locks in Park– Repair Procedure |
|
86-148 |
Driver’s Seat and Mirrors Control Module
–Loss of Seat or Mirror Functions –Repair Procedure |
|
86-150 |
In-Car Entertainment System –CD Button
Inoperative –Data Cable Diagnostic Procedure |
|
86-151 |
Deletion of Mirror Memory -Identifying
Modification |
|
86-159 |
Seat Control Module –Loss of Seat or Mirror
Functions –Repair Procedure |
|
86-163 |
Cooling Fans – Run Continuously –Switch
Harness Repair |
|
86-168 |
Inadvertent Radio Antenna Operation
–Hands-free Operation –Cellular Telephone |
|
86-176 |
Compact Disc Changer – LXF 4160CA –1993-94
MY Sedan Range Installation Instructions |
|
86-177 |
Trunk Latch – Modified Part –Install Using
Short Screw |
|
86-178a |
Inoperative Blue Relay .Oxidized or Damaged
Terminals .Checking/Replacement Guidelines |
|
86-179 |
Poor Antenna Mast
Operation –Cleaning – Replacing |
|
88-19 |
Erratic Fuel Gauge - Sender Unit Float
RodSticking - Replace Sender Unit |
|
88-20 |
Engine Oil Pressure – Incorrect Low
OilPressure Warning – Repair Procedure |
|
3-120 |
Motorized Automatic Diagonal Seat Belts |
|
76-64 |
Tibbe Door Locks |
|
AJ6 4.0 |
AJ6 4.0 Engine Management System |
